In the wake of Toyota's huge floor mat recall, theorists have come up with several survival strategies designed to overcome a throttle that's stuck wide-open. Putting some of these theories to the test – and debunking several myths in the process – is the team over at Consumer Reports.
With a large test track and a fleet of vehicles at their disposal, the magazine's engineers initially focused on the "just step hard on the brakes" method of bringing the car to a halt. Interestingly enough, CR tested a Mercedes-Benz E350 and a Volkswagen Jetta Wagon – both fitted with drive-by-wire "smart throttles" that are designed to ignore conflicting inputs (throttle and brake at the same time). CR reports that these cars simply shut down to idle and came safety to a stop. The story was a bit different with a Toyota Venza and Chevrolet HHR, however. When the brakes on those vehicles were firmly applied at 20 mph, their transmissions downshifted to fight the deceleration. The vehicles were both eventually brought to a stop after the first test. However, when the test was repeated at 60 mph on brakes that had been cooled since the earlier run, both vehicles quickly suffered fade from their overheated brakes and were unable to come to a complete stop.
more ...
Good news for those of you who happen to own a Toyota or Lexus vehicle sans floormats, as the Japanese automaker has reportedly come up with a solution to the 3.8 million-vehicle recall announced last week. We haven't reviewed the documentation ourselves, but it sounds as if the answer is to zip tie the driver's side floormat to the seat rails.
Toyota spokesman Brian Lyons tells Automotive News that dealers all around the country should have gotten the instructions on the so-called "semipermanent floormat installation process," which means they can continue to sell new and used vehicles with floormats in place.
Plus, dealerships are being instructed to attach a note to the nylon wire-tie instructing dealers and customers to ensure the mats are properly affixed. The warning also notes that owners should never stack multiple mats on top of one another(!). Apparently, this bit of discount MacGyvery satisfies the National Highway Traffic Safety Administration. If you own one of the recalled models, perhaps it's time to visit your dealership to get the fix taken care of.
Coming hard on the heels of its largest U.S. recall in history is news suggesting that Toyota could again face the wrath of the National Highway Traffic Safety Association. That's because the government agency is finally turning its eyes on the frame rust problem for 2000-2001 Toyota Tundras, a problem that has lit up owner forums for years. Toyota is no stranger to frame rust issues, as it has also extended the rust warranty of 1995-2000 Tacoma trucks and has even offered to buy back the trucks in 20 cold weather states at 1.5 times their Kelley Blue Book values. 2001 to 2004 Tacomas are already eligible for supplemental corrosion protection and replacement frames if necessary, but Toyota will not buy the newer trucks back.
The latest probe by NHTSA involves 218,000 Tundras from the 2000 and 2001 model year, as the government safety organization has reportedly received 20 reports of frames that have rusted to the point where some serious problems occurred. Five of the reports were for brake lining ruptured on the driver's side "rear crossmember at upper shock mount." The other 15 reported incidences involved spare tires which separated from the rear crossmember as the result of excessive rust. Sean Kane, president of Safety Research & Strategies told The Detroit News that the frame rusting problem is so severe that the "bottom can collapse." We take that as meaning that the frame of the Tundra truck can collapse under its own weight due to advanced tinworm.
more ...
Toyota has begun working with the National Highway Traffic Safety Administration to recall 95,700 vehicles with a brake issue that could lead to poor stopping at low temperatures. The recall involves 2009 and 2010 Toyota Corolla and Matrix models and 2008-2009 Scion xD models with the 1.8-liter engine, and only customers in 19 cold weather states are eligible for the recall.
Toyota says the problem may arise when condensed moisture from the positive crankcase ventilation port seeps into the brake system vacuum port and freezes. As ice accumulates, the brake vacuum port could plug up and "power assist to the brakes would gradually decrease and lead to lengthened vehicle stopping distances." That doesn't sound good. Owners of affected vehicles will soon receive a notice from Toyota, followed by instructions to take the vehicle to a Toyota dealership for no-cost repairs. Dealer technicians will install a newly designed intake air connector that relocates the brake system vacuum port, a one-hour procedure.
While it's definitely a good thing that Toyota caught this issue as soon as it did, we have a bit of an issue with the fact that the recall is only for cold weather states. It's not like a Corolla or Matrix can't cross state lines during winter, and nobody deserves to be met with brakesicles when they try to stop.
Levi Stewart lost his life after the steering relay rod on his 1991 Toyota pickup snapped, causing the truck to roll. Officials labeled the accident alcohol-related due to the fact the teenager had a blood-alcohol level of .03 (legal limit for adults in his state over the age of 21 is .08), but that was before anyone involved with the investigation knew of a National Highway Traffic Safety Administration recall. The relay rod, which connects the steering wheel to the front tires, had been under recall since 2005, but neither the truck owner or the previous owner had been notified of the defect. Lawyers for the Stewart family are accusing Toyota of both delaying and improperly distributing the recall notice, which affected 1 million trucks and SUVs. The lawyers contend they have evidence that Toyota has known about the problem since as early as 1996, yet the recall didn't begin until 2005. Toyota actually started the recall in Japan a year earlier, and Toyota waited a full year before starting the recall action in the U.S. The reason Toyota has stated for the delay was that driving conditions were different in Japan, and that there were no incidents reported in the U.S. Japanese media told NBC that it knew of 80 incidents in Japan.more ...
Slightly more than 90,000 Toyota Highlanders are being recalled for a seatbelt problem in the third row. The recalled crossovers are all 2008 models built between May of 2007 and March of this year. The stock belts could prevent secure mounting of a rear-facing child seat in the third row, and dealers will install a redesigned part on affected Highlanders. The problem with the third row belts hasn't spawned any complaints or injuries, and owners will be notified starting in June. Still, Toyota has put the brakes on Highlander sales until current stock is retrofitted and assembly lines are resupplied with the new part.
